300型丁基腻子钢板止水带

300型丁基腻子钢板止水带  131 6657 0832

钢板橡胶止水带是将镀锌钢板插入硫化好的橡胶中，橡胶采用国产一级特种橡胶与促进剂量、防老剂等，经混炼、挤压后与镀锌钢板粘合而成的一种新型接缝止水产品。这种止水带可以有效地防止各种荷载下产生的弹性、变形及施工缝的温差变化，起到坚固密封。并且能有效的防止施工缝漏水，渗水，并对各种作用力起到缓冲作用。本产品具有耐老化性能优良，特强的自粘性；夏季高温不流淌。冬季低温不发脆；并具有优异的耐水、耐酸碱和耐老化性能；使用寿命长，产品本身无毒，环境良好。为了承受一定的弯曲和压力。中间来有0.4或0.6mm的钢板。本产品可以对建筑缝之间提供可靠的防水、防渗功能。当使用普通橡胶止水带时，如果建筑结构变形大时，橡胶止水带则随着结构的沉降，其横向截面拉长，变薄，超过其疲劳变形极限时，很可能会形成新的渗漏缝隙。我们可以根据用户要求生产各种非标型号的产品，并满足各种工程上的实际需要。适用于许多大型建筑领域，尤其是在水压高和结构变形量较大时，其止水效果更为明显。

300型丁基腻子钢板止水带  131 6657 0832

Steel plate rubber sealing strip is inserted into the good will of galvanized steel plate vulcanized rubber, rubber made of a special rubber antioxidant and promoting dose, etc., a new type of sealing products through mixing, extrusion and galvanized steel plate bonding. The waterproof belt can effectively prevent the elastic, deformation and the temperature difference of the construction joint under various loads, and thus the strong sealing can be achieved. And can effectively prevent the construction joints leakage, seepage, and the role of a buffer role. This product has good aging resistance, strong self adhesion; summer high temperature does not flow. Low temperature and no brittleness in winter, and has excellent water resistance, acid and alkali resistance and aging resistance, long service life, non-toxic products, good environment. In order to withstand certain bending and pressure. There are 0.4 or 0.6mm steel plates in the center. This product can provide reliable waterproof and anti-seepage function between building joints. When using the ordinary rubber sealing strip, if the building structure of large deformation, the rubber sealing strip with the settlement of the structure, the transverse section of elongated, thin, more than the fatigue limit of deformation, it is likely to form a new leakage gap. We can produce all kinds of non-standard products according to the requirements of users, and meet the actual needs of various projects. It is suitable for many large building fields, especially when the water pressure is high and the structure deformation is large, the sealing effect is more obvious.

300型丁基腻子钢板止水带  131 6657 0832

我公司可以生产各种规格的钢板腻子止水带产品，并可根据用户要求，生产各种非标型号的产品，满足工程上的实际需要。1、主要应用范围：隧道、地铁、堤坝、涵洞、水利水电工程中施工缝、高层建筑地下室、地下停车场等主要工程施工缝。

Our company can produce all kinds of steel plate putty waterproof belt products, and according to user requirements, the production of various non-standard models of products, to meet the actual needs of the project. 1, the main application scope: tunnel, subway, dam, culvert, water conservancy and hydropower project construction joints, high-rise building basement, underground parking lot and other major construction joints.

钢板腻子止水带的施工方法及注意事项

300型丁基腻子钢板止水带  131 6657 0832

Construction method and matters needing attention of steel plate putty water stop belt

A、将钢板腻子止水带膨胀腻子连接处搭接100mm，用手压紧排除空气靠其自身粘接牢固，并加固轧丝后重新贴上保护膜。

A, the steel plate putty water stop belt expansion putty connection place overlap 100mm, press the air by hand, firmly adhere to its own, and strengthen the rolling silk, again affixed with protective film.

B、将钢板膨胀腻子止水带安放在墙体的中间位置，用铁丝固定在钢筋上，止水带略高于混凝土介面。

B, the steel plate expansion putty water stop belt is placed in the middle of the wall, and the steel bar is fixed on the steel bar, and the water stop belt is slightly higher than the concrete interface.

C、再次浇注前，将橡胶止水带下端的保护膜取掉，混凝土浇注至钢板膨胀腻子宽度的1／21／3处，在二次浇注前将上端保护膜取掉，再进行浇注。而采用钢板橡胶止水带时，两边的钢板与周围的混凝土结构的粘接极强，同是钢板与橡胶粘接极其牢固。当结构变形时，只存在橡胶部分拉长，变薄，而钢板与混凝土、钢板与橡胶之间不会产生新的渗漏缝隙，因此，用钢板橡胶止水带即增强了结构变形时的防渗性能，同时对整个工程的防渗止水起到了重要的质量保证。

Before the C and re pouring, the protective film at the lower end of the rubber sealing strip is removed, and the concrete is poured to the 1 / 21 / 3 of the width of the expansion putty of the steel plate, and the upper protective film is taken out before the two pouring, and then the casting is carried out. While using steel plate rubber water stop, both sides of the steel plate and the surrounding concrete structure of the bond is strong, the same is the steel plate and rubber bonding is extremely strong. When the deformation of the structure, only the rubber part elongate, thin, but not between steel and concrete, steel plate and rubber leakage gap, new so that enhances the anti-seepage performance of structure deformation when using steel plate rubber waterstop, and seepage of the whole project played an important quality assurance.

300型丁基腻子钢板止水带  131 6657 0832

企业名片